ZA1000

ZA1000 SERIES
1KVA DC/AC INVERTERS
同期並列運転可能
Synchronized Parallel Operation
(Sine Wave Output)
■ Terminal Outs & Dimensions (±1.0mm)
26
26
430
10
50Hz 60Hz
+ -
REMOTE
ALARM
4-M4
OUTPUT
AC OUT
V U FG
3-M6
5 4
3 2 1
SYNC, OP.
C D
9 8 7 6
INPUT
DC IN
＋ − FG
13 12 11
2-M4
Air-Cooling Fan
3-M6
86
2
23
AIR
88×482×295 (mm)
■ Features
● 周波数切替スイッチ有り
● RoHS指令対応
250
295
22
2.3
5.9
Digital Meter
10
VOLTAGE
POWER
CURRENT
V
14
50
76.2
88
19インチラックサイズ (2U)
高効率 87％ typ.
入出力間絶縁 (AC2000V)
入力低電圧保護回路内蔵
入力過電圧保護回路内蔵
入力突入電流保護回路内蔵
過熱保護回路内蔵
＋85℃∼＋90℃
● 入力ヒューズ内蔵
● 入出力ノイズフィルタ内蔵
●
●
●
●
●
●
●
A
POWER ALARM OVER LOAD
ASIA ELECTRONICS IND.CO.,LTD.
8
8
466
5.9
Operation is possible
Fit to 19" (2U) rack system
High Efficiency 87％ typ.
Input-Output Isolation (AC2000V)
Input Low Voltage Protection
Input Over Voltage Protection
Input Rush Current Protection
Thermal Protection
＋85℃∼＋90℃
● Input Fuse Integrated
● Input and Output Noise Filter
Integrated
● Built-in Frequency Changing Switch
● Conforming to RoHS Directive
●
●
●
●
●
●
●
AIR
AIR
● 単独運転可能
● 複数の同期並列運転可能
7
● Single Operation is possible
● Plural Synchronized Parallel
482
■ General Characteristics
●
●
●
●
Input Voltage (DC)
Output Voltage
Output Current (rms)
Output Frequency, Accuracy
● Output Wave, Distortion
● Output Voltage
Temperature Coefficient
● Output Frequency
Temperature Coefficient
● Efficiency
● Line Regulation
● Load Regulation
● Short Circuit Protection
● Output Alarm Signal
● Remote ON/OFF Control
● Operating Ambient
Temperature
● Storage Temperature
● Isolation Voltage
● Isolation Impedance
●
●
●
●
Weight
Humidity
Shock
Vibration
● Surface Structure
● MTBF
● Warranty
(at Ta:25℃, Full Load, Nominal Vin)
DC24V,36V,48V, 96V (See Table 1)
AC100Vrms
See Table 1
50Hz/60Hz ±1Hz
Buiit-in changing switch
Sine Wave, 3％ max.
0.05％／℃ max.
0.05%／℃ max.
Terminal Outs and Function
1
2
3
4
5
6
7
8
9
10
11
See Table 1
0.5％ max. (at Vin Range)
AC103Vrms (0A Load)
AC100Vrms (5A Load)
AC97Vrms (10A Load)
Built-in (See Fig 2)
Normal : Open between terminals
Abnormal : Short between terminals
(Output is shut down)
ON:open, OFF:short
−25℃∼＋50℃
−40℃∼＋85℃
AC2000V one minute
(Input−Output−Case)
100MΩ min. (at DC1000V)
(Input−Output−Case)
9kg
20∼90％ R.H.
196m/s2 (11msec 3directions)
10∼55Hz 19.6m/s2
(30minutes 3directions)
6 Sided Metal Case
100,000H
(Ta:25℃, 80％Load, Nominal Vin)
3 years
12
13
14
＋Vdc in
−Vdc in
Frame Ground (FG)
Sync. Ope. (C)
Sync. Ope. (D)
+ Remote (ON/OFF)
- Remote (ON/OFF)
Alarm Signal
Alarm Signal
Frequency Changing Switch
AC out (V)
AC out (U)
Frame Ground (FG)
ON/OFF Switch
■ Selection Guide
Table 1
Input Volt.
(Range)
(V. DC)
Output
Voltage
(V. AC)
Output
Current
(A r ms)
ZA1000-24-100S10A
24
(18∼36)
100
ZA1000-36-100S10A
36
(27∼54)
ZA1000-48-100S10A
ZA1000-96-100S10A
Model Number
Efficiency
(Typical)(％)
20%
Load
80%
Load
10
86
87
100
10
86
87
48
(36∼76)
100
10
86
87
96
(72∼144)
100
10
86
87
※ 上記仕様以外にも対応可能ですのでお問い合わせ下さい。
Please consult with us about other specification.
ZA1000 SERIES
DATA SHEET
■ Block Diagram
Interception
Relay
Voltage
Sensor
Reverse
Connection
Protector
12 AC out(U)
□
DC/AC Inverter
Drive Circuit
Rush Current
Protector
-Vin □
2
Rectifier Circuit
+Vin □
1
Current
Sensor
11 AC out(V)
□
3
FG □
13 FG
□
Control
Control
FG
6
+ RC(ON/OFF) □
7
- RC(ON/OFF) □
8 Alarm
□
9 Alarm
□
Detector
14
SW □
Voltage Meter
4
Sync.Ope(C) □
Sync.
Control
5
Sync.Ope(D) □
Current Meter
Isolation Amp
Frequency Changing
10
Switch (50Hz or 60Hz) □
Fan
■ Characteristic Curves
■ 主な機能及び注意事項
Function and direction in application
Output Current (％)
Fig 1 Derating Curve
140
同期並列運転方法（10台まで可能）
120
（注、設定周波数は必ず同じにして下さい。）
（注、端子の接続を間違えると破損することがあります。）
100
Synchronized parallel operating method
(ZA1000 is able to synchronize to 10 sets.)
※Use all ZA1000 at the same frequency.
※ZA1000 may be damaged if you make a mistake
in connection of terminals. 80
60
40
20
0
-20 -10
0
10
20
30
40
50
60
70
80
90 100
Temperature (℃)
Fig 2 Short Circuit Operating Area
DC
Output Voltage (％)
140
120
1
+Vdc in
−Vdc in
3
4
1
ZA1000
(1)
Sync.Ope(C)
4
5
Sync.Ope(D)
2
AC out(V)
AC out(U)
11
AC out(V)
AC out(U)
11
AC out(V)
AC out(U)
11
AC out(V)
AC out(U)
11
12
100
80
DC
60
1
+Vdc in
2
−Vdc in
3
4
1
4
5
40
Sync.Ope(C)
Sync.Ope(D)
ZA1000
(2)
12
20
0
0
80
100
120
140
160
180
200
DC
Output Current (％)
1
+Vdc in
2
−Vdc in
3
4
1
4
5
※出力過負荷が10∼15秒間続くと、出力が停止します。
入力再投入で、出力電圧が復帰します。
Sync.Ope(C)
Sync.Ope(D)
ZA1000
(3)
12
※When an output overload continues 10-15 seconds,
the output stops.
By an input reintroduction, the output voltage returns.
DC
Fig 3 Efficiency vs. Output Current
Vin=36V
2
4
5
90
80
Vin=48V (Nominal Voltage)
70
Vin=72V
60
50
ZA1000-48-100S10A
40
0
1
3
4
1
100
Efficiency (％)
AC
(V)
0
10
20
30
40
50
60
70
Output Current (％)
80
90
100
+Vdc in
−Vdc in
Sync.Ope(C)
Sync.Ope(D)
ZA1000
(10)
12
AC
(U)

Download Report