AS/NZS 61000.6.3: 2012

AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 1 of 11
Doc Id: TR-EMC (2012-01-30)
COMPLIANCE TESTING REPORT TO
AS/NZS 61000.6.3: 2012
Client:
EBBS International Pty Ltd
Address:
43 Orlando Road, Lambton, NSW 2299, Australia
Report Number:
0704EBB_TODDLER_61000-6-3
Date of Testing:
02 to 03 Jul 2014
File Number:
EBB140611
Equipment Name:
EBBS Toddler
Equipment Model Number:
EBBS Toddler
Equipment Serial Number:
Not indicated
Equipment Description:
Electronic Body Buoyancy System
Result:
COMPLIES (Refer to Test Summary page for clarifications)
Tested by:
Phillip Kane
Approved by:
Colin Gan
Senior Engineer
Date of Issue:
04 Jul 2014
Results appearing herein relate only to the sample(s) tested.
This report is issued errors and omissions exempt and is subject to withdrawal at Austest Laboratories discretion.
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 2 of 11
Doc Id: TR-EMC (2012-01-30)
Table of Contents:
1
2
3
4
TEST SUMMARY...................................................................................................................3
MODIFICATIONS...................................................................................................................3
EQUIPMENT UNDER TEST (EUT) DESCRIPTION...............................................................4
EUT TEST SETUP & CONFIGURATION ...............................................................................4
4.1 Supporting Equipment...................................................................................................4
4.2 Cables...........................................................................................................................5
5
TEST SPECIFICATIONS .......................................................................................................5
5.1 Accreditations & Listings ...............................................................................................5
5.2 Deviations from Standards and/or Accreditations ..........................................................5
5.3 Test Facility...................................................................................................................5
5.4 Test Equipment .............................................................................................................6
5.5 Measurement Uncertainties...........................................................................................6
6
AS/NZS 61000-6-3: 2012 RADIATED EMISSIONS................................................................7
6.1 EUT Operating Mode ....................................................................................................7
6.2 Test Method ..................................................................................................................7
6.3 Test Results ..................................................................................................................7
APPENDIX A – PHOTOGRAPHIC RECORD OF EUT ....................................................................9
APPENDIX B – EUT TEST SETUP PHOTOGRAPHS...................................................................11
Report Revision History:
Date
04 Jul 2014
Report Number
0704EBB_TODDLER_61000-6-3
Changes
Original Report.
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 3 of 11
Doc Id: TR-EMC (2012-01-30)
1
TEST SUMMARY
Austest makes no claim regarding the consistency of production versions of the EUT.
The results in this report apply only to the tested EUT described in Section 3 of this report.
Test
Result
Notes
Emissions - AS/NZS 61000.6.3: 2012
Radiated Emissions
Complies
Conducted Emissions (AC Power Ports – 0kHz to 2kHz)
NA
(v)
Conducted Emissions (AC Power Ports – 0.15MHz to
30MHz)
NA
(iv)
Conducted Emissions (AC Power Ports – Discontinuous
Disturbance)
NA
(iv)
Conducted Emissions (DC Power Ports)
NA
(iv)
Conducted Emissions (Telecommunication Ports)
NA
(iv)
Notes (applicable only if referenced in “Notes” column of above summary table):
(i)
EUT complies (the measurement results were below the applicable limits), but some
emissions were within the range of measurement uncertainty of the limits.
(ii) EUT complies (when modified as described in Section 2 of this report).
(iii) There were deviations from the applied standard as described in Section 5.2 of this
report.
(iv) These tests are not applicable to the EUT based on the conditions for applicability in
the applied standard.
(v) Not required for RCM / C-Tick compliance.
2
MODIFICATIONS
None.
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 4 of 11
Doc Id: TR-EMC (2012-01-30)
3
EQUIPMENT UNDER TEST (EUT) DESCRIPTION
EUT Name:
EBBS Toddler
EUT Description:
Electronic Body Buoyancy System
EUT Model:
EBBS Toddler
EUT Serial Number:
Not indicated
Manufacturer:
EBBS International
Power Supply & Rating:
3.7VDC LIPO Battery
Highest Clock/Operating
Frequency:
4MHz (as declared by client)
The EUT is an electronic device used with a canister to inflate a bladder with carbon dioxide
to provide buoyancy when triggered by pressure. The EUT contains the following modes;
1. Sleep mode, consuming virtually no power.
2. Sense mode, consuming about 2mA.
3. Trigger mode, one off event lasting approximately 3 seconds deploying the device.
Due to the nature of the operation of the device it was determined that the EUT would be
configured in Sense mode for final testing.
4
EUT TEST SETUP & CONFIGURATION
Refer to the photographs in APPENDIX B – EUT TEST SETUP PHOTOGRAPHS for the
EUT test setup and physical configuration.
Details of supporting equipment and cables used are listed as follows:
4.1
Supporting Equipment
Equip. No.
Equipment
Brand & Model
Serial No.
NA
NA
NA
NA
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 5 of 11
Doc Id: TR-EMC (2012-01-30)
4.2
Cables
Equip. No.
Cable
Type
Length
NA
NA
NA
NA
5
TEST SPECIFICATIONS
5.1
Accreditations & Listings
None.
5.2
Deviations from Standards and/or Accreditations
None.
5.3
Test Facility
Testing was performed in South Australia at Austest Laboratories (SA)’s test facilities located
at:
Main Laboratory:
Unit 3, No. 4 Aristotle Close, Golden Grove, SA 5125, Australia.
(2.4m x 2.4m x 7.2m shielded enclosure, equipped with power and
telecommunications line filters.)
Open Area Test Site
(OATS):
Corner of Fox Creek Road and Lobethal Road, Cudlee Creek, SA
5232, Australia.
(10m OATS, equipped with 360 degree remote control turntable and
6m remote control antenna mast.)
Radiated emission testing is performed at an Open Area Test Site (OATS), where some
ambient signals may exceed the continuous disturbance limit. The possibility of missing an
emission during testing is removed by use of pre-scans, performed in a shielded enclosure,
prior to the final OATS measurements.
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 6 of 11
Doc Id: TR-EMC (2012-01-30)
5.4
Test Equipment
All critical items are maintained on a scheduled calibration recall program, or verified with
equipment maintained on a scheduled calibration program. Emission measurements are
traceable to Australian National standards or international equivalents.
5.5
Measurement Uncertainties
The following uncertainties are for a 95% level of confidence, based on a coverage factor,
k=2.
Test
Radiated Emissions (Austest SA)
Measurement Uncertainty
±4.9dB
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 7 of 11
Doc Id: TR-EMC (2012-01-30)
6
AS/NZS 61000.6.3: 2012 RADIATED EMISSIONS
Test Date:
Test Officer:
Test Location:
6.1
10.2 oC
81 %
EUT power supply voltage - 3.7VDC LIPO Battery.
The EUT was configured in Sense mode by shorting the two touch pads together with
alligator clips. Final results are based on this mode and configuration.
Test Method
a.
b.
c.
d.
e.
6.3
Temperature:
Humidity:
EUT Operating Mode
a.
b.
6.2
03 Jul 2014
Phillip Kane
Austest Laboratories (SA)
Measurements were performed in accordance with the standard.
Measuring receiver BW was set to 120kHz (30MHz to 1GHz) EMI Receiver BW.
The EUT was set up on a non-conductive turntable, 0.8m above the OATS conductive
ground plane, and at the indicated test distance away from the measuring antenna.
Each emission to be measured was maximised by rotating the EUT through 360o and
adjusting the measuring BiLog antenna height between 1m to 4m in both vertical and
horizontal polarizations.
The maximised emission was measured and the above repeated for all measurement
frequencies.
Test Results
No tabulated results are provided as no significant EUT emissions were found.
Graphs shown in this Section are obtained using a Peak detector with the EUT and antenna
positions fixed. The green trace is the test site ambient profile and the black trace is the
combined effect of ambient emissions and the EUT. Differences between traces were
investigated to determine whether they were ambient or EUT emissions. The investigations
were supplemented by pre-scan plots done in a screened room prior to the radiated
emissions test. Only EUT emissions are reflected in the tabulated results given. Limit line is
shown in red.
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 8 of 11
Doc Id: TR-EMC (2012-01-30)
Radiated Emissions Plot (Vertical Polarisation, 30MHz to 1GHz)
Radiated Emissions Plot (Horizontal Polarisation, 30MHz to 1GHz)
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 9 of 11
Doc Id: TR-EMC (2012-01-30)
APPENDIX A – PHOTOGRAPHIC RECORD OF EUT
EUT Top
EUT Bottom
EUT Canister port
EUT Side
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 10 of 11
Doc Id: TR-EMC (2012-01-30)
EUT with Canister
EUT with Accessories
This document shall not be reproduced in any form except in full.
AS/NZS 61000.6.3 Test Report
No: 0704EBB_TODDLER_61000-6-3
Page 11 of 11
Doc Id: TR-EMC (2012-01-30)
APPENDIX B – EUT TEST SETUP PHOTOGRAPHS
Radiated Emissions Test Setup
This document shall not be reproduced in any form except in full.

Download Report